Ford Fusion: Instrument Panel and Console / Specifications

Ford Fusion 2013–2020 Service Manual / Body and Paint / Body and Paint / Instrument Panel and Console / Specifications

Torque Specifications

Item	Nm	lb-ft	lb-in
Evaporator flange nut	11	-	97
Floor console bolts	6.2	-	55
Glove compartment bolts	2.5	-	23
HVAC case nut	15	-	133
IPC bezel bolts	2.5	-	23
IPC	3	-	27
Instrument panel center register bolts	2.5	-	23
Instrument panel center support bolts	15	-	133
Instrument panel-to-body bolts	25	18	-
Instrument panel cowl bolts	25	18	-
Instrument panel cowl side bolts	35	26	-
Instrument panel LH trim panel bolts	2.5	-	23
Instrument panel upper section bolts	2.5	-	23
Passenger side airbag-to-in-vehicle cross beam bolts	10.5	-	93
Steering shaft pinch bolt	28	21	-

Instrument Panel and Console

Auxiliary Power Point. Removal and Installation

Special Tool(s) / General Equipment 501-039Remover, Power Point SocketTKIT-1998-FLMTKIT-1998-LM Removal WARNING: Before beginning any service procedure in this section, refer to Safety Warnings in section 100-00 General Information...

Other information:

Ford Fusion 2013–2020 Service Manual: Side Airbag. Removal and Installation

Removal WARNING: Front seat backrest trim covers installed on seats equipped with seat side airbags cannot be repaired. A new trim cover must be installed. Cleaning is permissible. Failure to follow these instructions may result in the seat side airbag deploying incorrectly and increase the risk of serious personal injury or death in a crash...

Ford Fusion 2013–2020 Service Manual: Windshield Wiper Motor. Removal and Installation

Removal NOTE: LH windshield wiper motor shown, RH windshield wiper motor similar. NOTE: Removal steps in this procedure may contain installation details. Remove the cowl panel. Refer to: Cowl Panel Grille (501-02 Front End Body Panels, Removal and Installation)...

Cross Traffic Alert System Sensors

Ford Fusion. Cross Traffic Alert System Sensors

The sensors are behind the rear bumper on both sides of your vehicle.